Cylinder Head Bolt Set - Mitsubishi Airtrek 2.0 Turbo-R 4WD CU2W

Complete set of 10 Bolts.
Choose from Aftermarket or Genuine Mitsubishi

Exploded Diagram HERE

Mitsubishi Part Number
MD191470

Water Pump Kit - Mitsubishi Airtrek 2.0 Turbo 4G63T CU2W

3 part kit consisting of
Water Pump, Water Pump Gasket & Water Rail O'Ring

Exploded Diagram HERE

Mitsubishi Part Number
MD977311 MD978552 MD975913
MD975644 1300A069

Lash Adjusters/Hydraulic Tappets x 16 for Mitsubishi Airtrek 2.0 Turbo-R 4WD CU2W 4G63T

Full Set of 16

These are the later type with 3mm oil hole.
Tappets are pre oiled ready for installation.

Exploded Diagram HERE

These are quality manufactured parts unlike some of our competitors
We buy in the 1000's to get the best possible price.
We then inspect each and every one for correct operation, hole size & burrs/poor finish.
If any defects are found the tappet is discarded.

Tappet Info & Bleeding Instructions HERE & HERE

Mitsubishi Part Numbers
MD124739 MD149309 MD337687 MD377054 85004200
2461039100 2461033050
EAN:-  84 27769 45510 0

Main Crank Pulley - Mitsubishi Airtrek 2.0 Turbo-R 4WD CU2W

This is a 2 part pulley glued together with rubber.
The rubber is there to provide engine damping ie to stop vibration.
However the rubber does perish and the pulley can fall apart
destroying the belt. See HERE & HERE

Mitsubishi Part Number
MD376059 1104A032

Exhaust Manifold to Cylinder Head Studs, Nuts & Washers Kit - Mitsubishi Airtrek 2.0 Turbo 4G63T CU2W

Complete Set of All the studs, nuts & washers
required to bolt the exhaust manifold to the cylinder head.
ONE COMPLETE 27 PART KIT COMPRISING OF THE PART NUMBERS BELOW

Mitsubishi Part Numbers
MD005317 now MD031537 x7
MD041192 x7
MR212302 x7
MD146938 x2
MD050076 x2
MR224500 x2

Mass/MAF Air Flow Sensor - Mitsubishi Airtrek 2.0 Turbo CU2W 4G63T

A Faulty one can cause some of these symptoms
The engine is very hard to start.
The engine intermittantly stalls.
The engine hesitates while under load or idle.
Hesitation and jerking during acceleration.
Excessively rich or lean idling.

SPECIAL ORDER 3 WEEKS APPROX

Choose from Genuine Mitsubishi or Aftermarket Copy

Mitsubishi Part Number
MR988286 E5T08173

Gates Cambelt Kit - Mitsubishi Airtrek 2.0 Turbo-R 4WD CU2W 4G63T

Complete Cambelt kit consisting of
1 x Gates Timing Belt
1 x Gates Balance Shaft Belt
1 x Cambelt Tensioner Bearing
1 x Upper Idler Bearing
1 x Balance Shaft Tensioner Bearing

Gates Belts OE quality as it gets without the Dealer Pricetag
Bearings are OE Manufacturers such as KOYO NTN NSK GMB

Exploded Diagram Showing Locations these are fitted is HERE

Mitsubishi Part Numbers
MD326059 MD327394 VP326059
MD156604 MD182537 MD334548
MD369999 MD352473 MD115976
MD192068
 

Idle Speed Controller - Stepper Motor - Idle Air Control Valve CU2W Airtrek 2.0 Turbo-R 4WD

If your engine idling is going up and down like a fiddlers elbow
then this could well be the reason.

Genuine Mitsubishi Part - Special Order from Japan approx 3-4 weeks

For an Exploded Diagram of inlet manifold and Throttle body
Click HERE

Mitsubishi Part Numbers
MD628166 MD628318 1450A069